WiredRite SST- 4 Manual do Operador Página 1

1213 1200.01 1 LOAD RITE Trailers, Inc. 265 Lincoln Highway Fairless Hills, PA 19030 215-949-0500 Trailer Operator’s Manual IMPORTANT INFORMATI

12213 1200.01 10 OPERATING INFORMATION AND PRE-TRIP CHECKLIST Always tie the boat securely at the bow and stern. Do not rely solely on the winch

1213 1200.01 11 BRAKE TROUBLESHOOTING A. Excessive travel in actuator mechanism: Possible cause: Corrective action: Low fluid in master c

1213 1200.01 12 D e p e n d i n g u p o n capacity, your trailer is equipped with a coupler that accepts either a 2” or 2-5/16" di

12213 1200.01 13 Once you are certain that your tow vehicle is equipped with a properly sized, rated, and positioned ball, raise the traile

1213 1200.01 14 If your tow vehicle is equipped with a five-wire, four-connector harness, it will be necessary to retrofit the vehicle with the

12213 1200.01 15 OPERATING YOUR TRAILER EQUIPPED WITH DISC BRAKES The disc brakes on your trailer function under the surge principle.

1213 1200.01 16 WARNING - LOAD RITE RECOMMENDS THAT ALL MAINTENANCE BE PER-FORMED BY A QUALIFIED MECHANIC. MAINTAINING YOUR TRAILER EQUIPPED W

12213 1200.01 17 WARNING - LOAD RITE RECOMMENDS THAT ALL MAINTENANCE BE PERFORMED BY A QUALIFIED MECHANIC. DISC BRAKE MAINTENANCE PRO

1213 1200.01 18 Carefully remove the rotor (or hub) from the spindle taking care to prevent the outer bearing from falling out of the hub

1213 1200.01 19 TIRE SAFETY INFORMATION 1.1. Tire Safety Information This portion of the User’s Manual contains tire safety information as requ

12213 1200.01 2 Table of Contents Introduction 2 Reporting Safety Defects 3 General Specifications 4 - 7 Tr

1213 1200.01 20 number. In any case, remember: the total weight of a fully loaded trailer can not exceed the stated GVWR. For trailers with liv

1213 1200.01 21 Subtract the empty weight of your trailer from the GVWR stated on the VIN label. That weight is the maximum available cargo cap

1213 1200.01 22 a manner that encloses the rim flanges inside the air cavity of the tire. Curb weight The weight of a motor vehicle with standa

1213 1200.01 23 The rim on which a tire is fitted for physical dimension requirements. Pin Weight The downward force applied to the 5th wheel o

1213 1200.01 24 weight or accessory weight, including heavy duty brakes, ride levelers, roof rack, heavy duty battery, and special trim. Radial

1213 1200.01 25 of wear of the tread. Vehicle capacity weight The rated cargo and luggage load plus 68 kilograms (150 lbs.) times the vehicle’s

1213 1200.01 26 Recognize that the time you spend is minimal compared with the inconvenience and safety consequences of a flat tire or other tir

1213 1200.01 27 1.6.4. Steps for Maintaining Proper Tire Pressure Step 1: Locate the recommended tire pressure on the vehicle's tire inform

1213 1200.01 28 1.6.9.1. Information on Passenger Vehicle Tires Please refer to the diagram below. P The "P" indicates the tire is

1213 1200.01 29 Speed Rating The speed rating denotes the speed at which a tire is designed to be driven for extended periods of time. The rati

1213 1200.01 3 IMPORTANT - PLEASE READ Please read this manual thoroughly and completely. A basic understanding of your trailer

1213 1200.01 30 1.6.9.2. UTQGS Information Treadwear Number This number indicates the tire's wear rate. The higher the treadwear number is,

1213 1200.01 31 Load Range This information identifies the tire's load-carrying capabilities and its inflation limits. 1.7. Tire Safety T

LOAD RITE Trailers, Inc. 265 Lincoln Highway Fairless Hills, PA 19030 215-949-0500 WARRANTY INFORMATION If you experience any difficulties or defects

12213 1200.01 4 GENERAL SPECIFICATIONS LOAD RITE is a registered member of the National Marine Manufacturers Association (NMMA) and th

1213 1200.01 5 Blue – disc brake free-backing solenoid, to be wired into tow vehicle back up lights The above wires each correspond with individ

12213 1200.01 6 Section F) and the bearing retainer or cotter pin. Always replace the retainer or cotter pin. DO NOT REUSE! Tighten the spindl

1213 1200.01 7 with cold galvanizing spray paint. This product can be obtained through any LOAD RITE dealer, or most paint, hardware, or marine

12213 1200.01 8 DETERMINING TONGUE WEIGHT (TW) NOTE. Gross trailer weight (GTW) is the actual weight of the trailer fully loaded (including tra

1213 1200.01 9 the rollers are fixed with no adjustment). NOTE: It is important to remember that boats with longitudinal strakes or chines shoul